Box-Behnken法优化加酸超声提取瞿麦中大黄素的工艺

doi:10.3969/j.issn.1000-1565.2017.04.007Box-Behnken法优化加酸超声

河北大学学报(自然科学版) ›› 2017, Vol. 37 ›› Issue (4): 369-377.DOI: 10.3969/j.issn.1000-1565.2017.04.007Box-Behnken法优化加酸超声

Box-Behnken法优化加酸超声提取瞿麦中大黄素的工艺

杨晓宇¹,李程²,马思跃¹,李建恒¹

收稿日期:2016-11-14 出版日期:2017-07-25 发布日期:2017-07-25
通讯作者: 李建恒(1964—),男,河北保定人,河北大学教授,主要从事中药药理方面的研究.E-mail:lijianheng@hbu.cn
作者简介:杨晓宇(1992—),女,河北邯郸人,河北大学在读硕士研究生. E-mail: 792033491@qq.com
基金资助:
河北大学自然科学研究计划项目(3333112)

Optimization of ultrasound extraction technology with acid of emodin from herba dianthi by response surface methodology

YANG Xiaoyu¹, LI Cheng², MA Siyue¹, LI Jianheng¹

1.College of Pharmaceutical Sciences, Hebei University, Baoding 071002, China; 2.College of Engineering, The University of Iowa, Iowan 52240, America

Received:2016-11-14 Online:2017-07-25 Published:2017-07-25

摘要/Abstract

摘要： 采用响应面法优化瞿麦中大黄素的提取工艺.利用单因素法进行考察,以大黄素提取量为指标,考察液固比、超声时间、温度、盐酸质量分数及用量对大黄素提取量的影响,并结合Design-Expert软件中的Box-Behnken实验设计和响应面分析方法对超声提取瞿麦中大黄素的工艺进行优化,再与药典中虎杖提取大黄素方法进行比较,确定大黄素超声提取最佳工艺:液固比为61倍,温度为40 ℃,超声30 min,加质量分数为8%的盐酸1 mL.通过优化得到的大黄素超声提取工艺省时,稳定,且与回流法相比提取量高.

关键词: 大黄素, 超声提取, 响应面法

Abstract: Response surface methodology was used to optimize the optimal ultrasound extraction technology of emodin from herba dianthi.With the amount of extraction of emodin as an indicator, single-factor test was used to investigate the effect of ethanol volume fraction, solid-liquid ratio, ultrasound time, temperature, mass fraction of hydrochloric acid and dosage on the amount of extraction of emodin.The results were combined with Box-Benhken design of design-expert software and response surface analysis to optimize the technology parameters for extraction process of herba dianthi, and compare with extraction technology of emodin from Polygonum cuspidatum in the Pharmacopoeia.Obtain the optimal ultrasound extraction technology under the following conditions: liquid- solid ratio was 61, 40 ℃,30 min, hydrochloric acid mass fraction 8%, 1 mL.Ultrasound extraction technology of emodin by response surface methodology is time-saving, stable, and the amount of extraction is higher than condensation reflux method.It’s provide theoretical basis for quality evaluation of Dianthus superbus.

Key words: emodin, ultrasound extraction technology, response surface methodology

中图分类号:

R917

杨晓宇,李程,马思跃,李建恒. Box-Behnken法优化加酸超声提取瞿麦中大黄素的工艺[J]. 河北大学学报(自然科学版), 2017, 37(4): 369-377.

YANG Xiaoyu, LI Cheng, MA Siyue, LI Jianheng. Optimization of ultrasound extraction technology with acid of emodin from herba dianthi by response surface methodology[J]. Journal of Hebei University (Natural Science Edition), 2017, 37(4): 369-377.

0
/ / 推荐

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://xbzrb.hbu.edu.cn/CN/10.3969/j.issn.1000-1565.2017.04.007Box-Behnken法优化加酸超声

https://xbzrb.hbu.edu.cn/CN/Y2017/V37/I4/369

参考文献

[1] 邬方宁.超声提取技术在现代中药中的应用[J].中草药, 2007,38(2):315.
[2] 国家药典委员会.中华人民共和国药典[S].北京:化学工业出版社,2015.
[3] 刘晨, 张凌珲, 杨柳, 等.瞿麦药学研究概况[J].安徽农业科学, 2011,39(33): 20387-20388,20392.DOI: 10.13989/j.cnki.0517-6611.2011.33.084. LIU C, ZHANG L H, YANG L,et al.Overview of pharmacological research on Dianthus superbus L.[J].Journal of Anhui Agri Sci, 2011,39(33): 20387-20388,20392.DOI: 10.13989/j.cnki.0517-6611.2011.33.084.
[4] 刘静, 王丽.大黄素的研究进展[J].中国药房, 2014,25(35): 3351-3354.
[5] 张新乐, 黄泽光, 薛晓英, 等.加酸提取何首乌中大黄素工艺的探讨[J].时珍国医国药, 2007,18(3): 571-572. ZHANG X L, HUANG Z G, XUE X Y, et al.HCl plus extract thchnology for emodin from radix polygoni multiflori[J].Lishizhen Medicine and Mareria Medica Research, 2007,18(3): 571-572.
[6] 蔡进章, 林崇良, 王贤亲, 等.6种蓼科植物药材大黄素含量比较[J].中华中医药学刊, 2012,30(6): 1372-1374. DOI: 10.13193/j.archtcm.2012.06.190.caijzh.066. CAI J Z, LIN C L, WANG X Q, et al.Determination and comparison of emodin in six kinds of polygonaceae herbs[J].Chinese Archives of Traditional Chinese Medicine, 2012, 30(6): 1372-1374.DOI: 10.13193/j.archtcm.2012.06.190.caijzh.066.
[7] 邹晶晶, 承伟.瞿麦中大黄素的含量测定[J].安徽农业科学, 2012,40(6): 3284-3285.DOI: 10.13989/j.cnki.0517-6611.2012.06.085. ZOU J J, CHENG W.Determination of emodin content in Dianthus superbus L.[J].Journal of Anhui Agri Sci, 2012,40(6): 3284-3285.DOI: 10.13989/j.cnki.0517-6611.2012.06.085.
[8] 侯学敏, 李林霞, 张直峰, 等.响应面法优化薄荷叶总黄酮提取工艺及抗氧化活性[J].食品科学, 2013,34(06): 124-128. HOU X M, LI L X, ZHANG Z F, et al.Total flavonoids from Mentha haplocalyx Criq Leaves: optimization of extraction process by response surface methodology and antioxidant activity[J].Food Science, 2013,34(06): 124-128.
[9] 杨文鸽, 谢果凰, 颜伟华, 等.响应面分析法优化海鳗的湿腌工艺[J].中国食品学报,2010,10(1):133-139.DOI: 10.16429/j.1009-7848.2010.01.010. YANG W G, XIE G H, YAN W H, et al.Optimization of wet-salting technology for Muraenesox Cinereus using resonse surface analysis[J].Journal of Chinese Instiute of Food Science and Technology, 2010,10(1): 133-139.DOI: 10.16429/j.1009-7848.2010.01.010.

Box-Behnken法优化加酸超声提取瞿麦中大黄素的工艺

Optimization of ultrasound extraction technology with acid of emodin from herba dianthi by response surface methodology

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 4

编辑推荐

Metrics

本文评价

[1]	邓天天,李晗晟,马培,徐梦醒,叶子昕,翟丽苹. 花生壳生物质炭的响应面法优化制备及其对水中Cr(Ⅵ)的吸附[J]. 河北大学学报(自然科学版), 2022, 42(4): 384-394.
[2]	高剑,孙焕然,国洪宾,陈保华,周程艳. 响应面法优化紫叶李皮中总多酚的提取工艺及其抗炎活性[J]. 河北大学学报(自然科学版), 2020, 40(2): 161-170.
[3]	杨雪莲,张凯丽,李金玉,张秋晨,王成涛. 响应面法优化酿酒酵母产3-甲硫基丙醇发酵条件[J]. 河北大学学报(自然科学版), 2014, 34(4): 398-404.
[4]	梁玉玲,鲜于梁艳,陈子龙. 白芷愈伤组织中总香豆素的提取与测定[J]. 河北大学学报(自然科学版), 2014, 34(3): 290-294,298.