Air gap eccentricity is a common mechanical fault in generators, the different operating parameters under air gap eccentricity will have an impact on the electromagnetic characteristics of generators. Previous researches mainly focused on the influence of axial air gap uniform eccentricity on the electromagnetic torque fluctuation characteristic. However, rare studies have considered the effects of variations in the axial air gap non-uniform eccentricity(inclination eccentricity). As a supplement, this paper comprehensively analyzes the effect of key operating parameters on electromagnetic torque characteristic in- DOI:10.3969/j.issn.1000-1565.2025.01.001轴向气隙非对称故障对发电机电磁转矩特性的影响何玉灵1,2,付滋翔1,代德瑞1,白洪华3,黄伟灵3(1.华北电力大学 机械工程系,河北 保定 071003;2.华北电力大学 苏州研究院,江苏 苏州 215123;3.浙江振兴阿祥集团,浙江 湖州 313000)摘 要:气隙偏心是发电机中常见的一种机械故障,气隙偏心下不同运行参数将对发电机的电磁特性造成影响.已有研究主要关注轴向气隙均匀偏心对电磁转矩波动的影响,较少关注轴向气隙非均匀偏心(倾斜偏心)所造成的影响.作为补充,该文全面分析了倾斜偏心下关键运行参数差异对发电机电磁转矩波动特性的影响.其中,关键运行参数主要包括倾斜偏心程度及发电机负载差异.整体工作以一台5 kVA的故障模拟发电机为研究对象,通过实验验证了理论分析和有限元分析得到的结果.结果表明:倾斜偏心会为电磁转矩带来额外的二倍频成分,且随着倾斜偏心角度的增大,电磁转矩的直流分量和二倍频成分都增大;随着负载的增加,发电机电磁转矩波动程度加剧,且直流分量和二倍频成分也将增大.关键词:发电机;负载差异;气隙非对称;电磁转矩中图分类号:TM311 文献标志码:A 文章编号:1000-1565(2025)01-0001-09Effect of axial air gap asymmetric fault on the characteristic of electromagnetic torque in generators HE Yuling1,2, FU Zixiang1, DAI Derui1, BAI Honghua3, HUANG Weiling3(1. Department of Mechanical Engineering, North China Electric Power University, Baoding 071003, China; 2. Suzhou Research Institute, North China Electric Power University, Suzhou 215123, China; 3. Zhejiang Zhenxing A Xiang Group Co., Ltd., Huzhou 313000, China)Abstract: Air gap eccentricity is a common mechanical fault in generators, the different operating parameters under air gap eccentricity will have an impact on the electromagnetic characteristics of generators. Previous researches mainly focused on the influence of axial air gap uniform eccentricity on the electromagnetic torque fluctuation characteristic. However, rare studies have considered the effects of variations in the axial air gap non-uniform eccentricity(inclination eccentricity). As a supplement, this paper comprehensively analyzes the effect of key operating parameters on electromagnetic torque characteristic in- 收稿日期:2024-03-29;修回日期:2024-05-07 基金项目:国家自然科学基金资助项目(52177042);河北省自然科学基金资助项目(E2022502003;E2021502038);中央高校基本科研业务费专项基金资助项目(2023MS128);河北省第三批青年拔尖人才支持计划(［2018］-27);河北省高层次人才项目(B20231006);苏州市社会发展科技创新项目(SS202134);河北省研究生创新能力培养项目(CXZZBS2023149);南太湖精英计划创新人才团队项目 第一作者:何玉灵(1982—),男,华北电力大学教授,博士生导师,博士,主要从事电站设备状态检测及其故障诊断. E-mail:heyuling1@163.com 通信作者:付滋翔(2000—),男,华北电力大学在读硕士研究生,主要从事发电机设备状态检测及其故障诊断. E-mail:fuzixiang2023@163.com 第1期何玉灵等:轴向气隙非对称故障对发电机电磁转矩特性的影响河北大学学报(自然科学版) 第45卷generator under inclination eccentricity. The key operating parameters include the degree of inclination eccentricity and generation load differences. The whole work was carried out on a 5 kVA fault simulated generator and the results obtained from the theoretical and finite element analysis were verified through experiments. It is shown that the inclined eccentricity introduces an extra double frequency component to the electromagnetic torque and that both the DC component and the second frequency component of the electromagnetic torque increase as the eccentricity angle grow. In addition, as the load increases, the fluctuating characteristics of the generators electromagnetic torque will be increased, and both the DC component and the 2nd harmonic will be increased as well.
HE Yuling
,
FU Zixiang
,
DAI Derui
,
BAI Honghua
,
HUANG Weiling
. Effect of axial air gap asymmetric fault on the characteristic of electromagnetic torque in generators[J]. Journal of Hebei University(Natural Science Edition), 2025
, 45(1)
: 1
-9
.
DOI: 10.3969/j.issn.1000-1565.2025.01.001
[1] 李永刚,贺鹏康,马明晗,等.基于轴承座振动特性的大型同步调相机偏心故障程度诊断方法[J].振动与冲击,2022,41(14):77-83. DOI: 10.13465/j.cnki.jvs.2022.14.011.
[2] KIM D J, KIM H J, HONG J P, et al. Estimation of acoustic noise and vibration in an induction machine considering rotor eccentricity[J]. IEEE Trans Magn, 2014, 50(2): 7021204. DOI: 10.1109/TMAG.2013.2285391.
[3] RAJALAKSHMI SAMAGA B L, VITTAL K P. Inclined mixed air gap eccentricity detection method for an induction motor[C] //2014 International Conference on Advances in Energy Conversion Technologies(ICAECT), IEEE, 2014: 37-41. DOI: 10.1109/ICAECT.2014.6757058.
[4] 马明晗,贺鹏康,李永刚,等. 高压直流输电换相失败对带静偏心故障调相机的影响[J]. 电力自动化设备, 2021,41(8): 189-193. DOI: 10.16081/j.epae.202107022.
[5] TONG W M, LI S Q, PAN X L, et al. Analytical model for cogging torque calculation in surface-mounted permanent magnet motors with rotor eccentricity and magnet defects[J]. IEEE Trans Energy Convers, 2020, 35(4): 2191-2200. DOI: 10.1109/TEC.2020.2995902.
[6] WAN S T, HE Y L. Investigation on stator and rotor vibration characteristics of turbo-generator under air gap eccentricity fault[J]. Trans Can Soc Mech Eng, 2011, 35(2): 161-176. DOI: 10.1139/tcsme-2011-0010.
[7] HE Y L, XU M X, ZHANG W, et al. Impact of stator interturn short circuit position on end winding vibration in synchronous generators[J]. IEEE Trans Energy Convers, 2021, 36(2): 713-724. DOI: 10.1109/TEC.2020.3021901.
[8] FAIZ J, MOOSAVI S M M. Review of eccentricity fault detection techniques in IMs focusing on DFIG[C] //2015 IEEE 5th International Conference on Power Engineering, Energy and Electrical Drives(POWERENG)IEEE, 2015: 513-520. DOI: 10.1109/PowerEng.2015.7266370.
[9] BRUZZESE C, JOKSIMOVIC G. Harmonic signatures of static eccentricities in the stator voltages and in the rotor current of No-load salient-pole synchronous generators[J]. IEEE Trans Ind Electron, 2011, 58(5): 1606-1624. DOI: 10.1109/TIE.2010.2087296.
[10] 万书亭,彭勃.气隙静偏心与转子匝间短路下电磁转矩特性区分[J].中国工程机械学报, 2021, 19(1): 65-71. DOI: 10.15999/j.cnki.311926.2021.01.012.
[11] JIANG H C, TANG G J, HE Y L, et al. Effect of static rotor eccentricity on end winding forces and vibration wearing[J]. Int J Rotating Mach, 2021, 2021: 5554914. DOI: 10.1155/2021/5554914.
[12] HE Y L, ZHANG Y Y, XU M X, et al. A new hybrid model for electromechanical characteristic analysis under SISC in synchronous generators[J]. IEEE Trans Ind Electron, 2020, 67(3): 2348-2359. DOI: 10.1109/TIE.2019.2907450.
[13] HE Y L, ZHANG W, XU M X, et al. Rotor loss and temperature variation under single and combined faults composed of static air-gap eccentricity and rotor inter-turn short circuit in synchronous generators[J]. IET Electr Power Appl, 2021, 15(11): 1529-1546. DOI: 10.1049/elp2.12118.
[14] 何玉灵,雷欢,张文,等.三维气隙偏心对同步发电机转子铁芯温度特性的影响[J].电力自动化设备, 2021,41(7): 196-202. DOI: 10.16081/j.epae.202103009.
[15] AKIYAMA Y, SUGIURA O. A study of 2sf beat phenomena in induction motor[C]. IEEE IAS Annual Meeting, 1992:100-106. DOI: 10.1109/IAS.1992.244458.
[16] OJAGHI M, MOHAMMADI M. Unified modeling technique for axially uniform and nonuniform eccentricity faults in three-phase squirrel cage induction motors[J]. IEEE Trans Ind Electron, 2018, 65(7): 5292-5301. DOI: 10.1109/TIE.2017.2760280.
[17] DORRELL D G. Sources and characteristics of unbalanced magnetic pull in three-phase cage induction motors with axial-varying rotor eccentricity[J]. IEEE Trans Ind Appl, 2011, 47(1): 12-24. DOI: 10.1109/TIA.2010.2090845.
[18] WANG X L, HE Y L, WANG H P, et al. A novel hybrid approach for damage identification of wind turbine bearing under variable speed condition[J]. Mech Mach Theory, 2022, 169: 104629. DOI: 10.1016/j.mechmachtheory.2021.104629.
[19] 何玉灵,孙凯,王涛,等.基于变分模态分解与精细复合多尺度散布熵的发电机匝间短路故障诊断[J].电力自动化设备, 2021, 41(3): 164-172. DOI: 10.16081/j.epae.202101014.
[20] 庞彬,周紫烨,齐晓帆,等.双馈异步风力发电机转子匝间短路故障振动特性分析[J].河北大学学报(自然科学版), 2024, 44(1): 9-16. DOI: 10.3969/j.issn.1000-1565.2024.01.002.
[21] 何玉灵.发电机气隙偏心与绕组短路复合故障的机电特性分析[D].北京:华北电力大学, 2012.
[22] 何玉灵,王发林,唐贵基,等.发电机气隙静态偏心对电磁转矩的影响[J].振动 测试与诊断, 2017, 37(5): 922-927, 1063. DOI: 10.16450/j.cnki.issn.1004-6801.2017.05.011.
[23] GARCÍA PEYRANO O, VIGNOLO J, MAYER R, et al. Online unbalance detection and diagnosis on large flexible rotors by SVR and ANN trained by dynamic multibody simulations[J]. J Dyn Monit Diagn, 2022: 139-147. DOI: 10.37965/jdmd.2022.58.
[24] ALGOLFAT A, WANG W Z, ALBARBAR A. Dynamic responses analysisof A 5MW NREL wind turbine blade under flap-wise and edge-wise vibrations[J]. J Dyn Monit Diagn, 2022: 208-222. DOI: 10.37965/jdmd.2022.108.
[25] XU Y D, TANG X L, FENG G J, et al. Orthogonal on-rotor sensing vibrations for condition monitoring of rotating machines[J]. J Dyn Monit Diagn, 2021, 1(1): 29-36. DOI: 10.37965/jdmd.v2i2.47.
[26] YESILYURT I, DALKIRAN A, YESIL O, et al. Scalogram-based instantaneous features of acoustic emission in grinding burn detection[J]. J Dyn Monit Diagn, 2021, 1(1): 19-28. DOI: 10.37965/jdmd.2021.49.
[27] SUN J H, GU X W, HE J, et al. A robust approach of multi-sensor fusion for fault diagnosis using convolution neural network[J]. J Dyn Monit Diagn, 2022: 103-110. DOI: 10.37965/jdmd.2022.95.
[28] WANG S K, ZHANG J. An intelligent process fault diagnosis system based on Andrews plot and convolutional neural network[J]. J Dyn Monit Diagn, 2022: 127-138. DOI: 10.37965/jdmd.2022.67. (
