Extraction technology optimization of total polyphenols from Prunus cerasifera by response surface methodology and corresponding anti-inflammatory activity investigation

doi:10.3969/j.issn.1000-1565.2020.02.008

Abstract

Abstract: This work aims to optimize the extraction technology of total polyphenols(PTP)from Prunus cerasifera and study its anti-inflammatory activity.Based on the results of the single-factor experiment,using extraction rate of total polyphenols as an index,volume fraction of ethanol,extraction time,extraction temperature and solid-liquid ratio as factors,the Box-Behnken experimental design and the response surface methodology were applied to optimize the extraction technology of PTP.The anti-inflammatory activities of PTP were studied via ear swelling induced by xylene and toe swelling induced by albumen.The results showed that the optimum extraction conditions of PTP were as follows: volume fraction of ethanol 69%,extraction time 1.5 h,extraction temperature 81 ℃,solid-liquid ratio at 1∶31(g∶mL).Under these conditions,the yield of PTP was 55.3 mg/g.PTP could effectively inhibit the inflammation of ear swelling of mouse and toe swelling of rats.The results suggested that optimized extraction technology was - DOI:10.3969/j.issn.1000-1565.2020.02.008响应面法优化紫叶李皮中总多酚的提取工艺及其抗炎活性高剑,孙焕然,国洪宾,陈保华,周程艳(河北大学药学院,河北省药物质量分析控制重点实验室,河北保定 071002)摘要:为了优化紫叶李(Prunus cerasifera)皮中总多酚(PTP)提取工艺并研究其抗炎活性,在单因素实验的基础上,以总多酚得率为考察指标,乙醇体积分数、提取时间、提取温度、料液比为考察因素,采用Box-Behnken实验设计结合响应面分析法优化PTP的提取工艺,通过二甲苯致耳肿胀法、蛋清致足趾肿胀法测定PTP的抗炎活性.实验结果表明,PTP的最优工艺条件:乙醇体积分数69%、提取时间1.5 h、提取温度81 ℃、料液比1∶31(g∶mL),该工艺下得率为55.3 mg/g.PTP能抑制小鼠耳廓及大鼠足趾炎症.结论是该提取工艺稳定可靠,得率较高,且PTP具有明显的抗炎活性.关键词:紫叶李;总多酚;响应面法;提取工艺;抗炎活性中图分类号:R284.2 文献标志码:A 文章编号:1000-1565(2020)02-0161-10Extraction technology optimization of total polyphenols from Prunus cerasifera by response surface methodology and corresponding anti-inflammatory activity investigationGAO Jian,SUN Huanran,GUO Hongbin,CHEN Baohua,ZHOU Chengyan(Key Laboratory of Pharmaceutical Quality Control of Hebei Province,College of Pharmaceutical Science,Hebei University,Baoding 071002,China)Abstract: This work aims to optimize the extraction technology of total polyphenols(PTP)from Prunus cerasifera and study its anti-inflammatory activity.Based on the results of the single-factor experiment,using extraction rate of total polyphenols as an index,volume fraction of ethanol,extraction time,extraction temperature and solid-liquid ratio as factors,the Box-Behnken experimental design and the response surface methodology were applied to optimize the extraction technology of PTP.The anti-inflammatory activities of PTP were studied via ear swelling induced by xylene and toe swelling induced by albumen.The results showed that the optimum extraction conditions of PTP were as follows: volume fraction of ethanol 69%,extraction time 1.5 h,extraction temperature 81 ℃,solid-liquid ratio at 1∶31(g∶mL).Under these conditions,the yield of PTP was 55.3 mg/g.PTP could effectively inhibit the inflammation of ear swelling of mouse and toe swelling of rats.The results suggested that optimized extraction technology was - 收稿日期:2019-08-20 基金项目:河北省科技计划项目(B2015201016);保定市科学技术研究与发展指导计划项目(18ZF121) 第一作者:高剑(1995— ),男,安徽六安人,河北大学在读研究生,主要从事药物的提取、设计与合成. E-mail: 1741452250@qq.com 通信作者:周程艳(1976— ),女,河北唐山人,河北大学副教授,主要从事药理作用机制,药效学,中药药效和有效成分筛选的研究.E-mail:893927534@qq.com第2期高剑等:响应面法优化紫叶李皮中总多酚的提取工艺及其抗炎活性considered to be stable and reliable.The yield of PTP was higher in extraction rate,and it can be obvious anti-inflammatory activity.

Key words: Prunus Cerasifera, total polyphenols, response surface methodology, extraction technology, anti-inflammatory activity

CLC Number:

R284.2

GAO Jian,SUN Huanran,GUO Hongbin,CHEN Baohua,ZHOU Chengyan. Extraction technology optimization of total polyphenols from Prunus cerasifera by response surface methodology and corresponding anti-inflammatory activity investigation[J]. Journal of Hebei University (Natural Science Edition), 2020, 40(2): 161-170.

References

[1] 易春霞,洪正山,谭柳萍,等.桑寄生抗炎作用的初步实验研究[J].药学研究,2019,38:70-72.DOI: 10.13506/j.cnki.jpr.2019.02.002.
[2] 种新禄,侯晓林,陈佳佳,等.诃子中总多酚粗提取工艺及药理作用研究[J].北京农学院学报,2014,29:64-67.DOI: 10.13473/j.cnki.issn.1002-3186.2014.0055.
[3] 全云云,袁岸,龚小红,等.连翘抗炎药效物质基础筛选研究[J].天然产物研究与开发,2017,29:435-438.DOI: 10.16333/j.1001-6880.2017.3.013.
[4] 祖元刚,胡艳,姜守刚.红松多酚物质的提取工艺及其抗炎活性初步研究[J].植物研究,2016,36:634-640.DOI: 10.7525/j.issn.1673-5102.2016.04.021.
[5] 鲁玉妙,马惠玲.我国植物多酚研究文献计量及研究热点分析[J].食品科学,2012,33:290-296.DOI: 1002-6630(2012)17-0290-07.
[6] SONG W,QIN S T,FANG F X,et al.Isolation and purification of condensed tannin from the leaves and branches of Prunus cerasifera and its structure and bioactivities[J].Applied Biochemistry and Biotechnology,2018,185: 464-475.DOI:10.1007/s12010-017-2635-9.
[7] JAFFRI SB,AHMAD KS.Prunus cerasifera Ehrh fabricated ZnO nano falcates and its photocatalytic and dose dependent in vitro bio-activity[J].Central European Journal of Chemistry,2018,16: 141-154.DOI:10.1515/chem-2018-0022.
[8] 吴丽红,任丽英,陈志钢.紫叶李果实总黄酮抗氧化性能实验研究[J].中国药业,2017,26:15-19.DOI: 10.3969/j.issn.1006-4931.2017.05.004.
[9] 王全,李红亚,李术娜,等.Box-Behnken设计响应面法优化超声波辅助双水相法提取玛咖多糖[J].河北大学学报(自然科学版),2016,36(4):387-395.DOI:10.3965/j.issn.1000-1565.2016.04.010.
[10] 冯子旺,俞力超,李峰,等.正交试验优选桑黄多酚超声提取工艺[J].中国药房,2012,23:221-222.DOI: 10.6039/j.issn.1001-0408.2012.03.10.
[11] 刘伟,蒲晓林,谢彬强.茶多酚制取工艺研究进展[J].化工时刊,2006(9):73-77.DOI: 10.16597/j.cnki.issn.1002-154x.2006.09.026.
[12] 黄丽晶,高文远,李霞,等.平贝母水提物抗炎作用研究[J].天津中医药,2009,26:495-496.DOI: 1672-1519(2009)06-0495-02.
[13] 束雅春,朱萱萱,陈亚军,等.不同后下时间银翘散汤剂抗炎活性谱效关系研究[J].中华中医药杂志,2018,33:4161-4166.
[14] 郭佳佳,刘海,朱燕红,等.蒙药芯芭提取物的抗炎、镇痛作用研究[J].中国药房,2017,28:64-67.DOI:1001-0408(2017)01-0064-04.
[15] 刘莹,杨海燕,陈艳成,等.响应面法优化裸花紫珠叶中苯乙醇苷的醇提取工艺[J].天然产物研究与开发,2018,30:495-500.DOI:10.16333/j.1001-6880.2018.3.024.
[16] 汪洪涛,陈成,余芳,等.紫叶李果实中总多酚的抑菌性及稳定性研究[J].食品工业,2014,35:195-198.
[17] FERIT C,MUTTALIP G,SEVKET A,et al.Determination of phenolic compounds,antioxidant capacity and organic acids contents of prunus domestica L,prunus cerasifera ehrh.And prunus spinosa L.fruits by HPLC[J].Acta Chromatographica,2017,29: 507-510.DOI:10.1556/1326.2017.00327.
[18] GERARDI C,FRASSINETTI S,CALTAVUTURO L,et al.Anti-proliferative,anti-inflammatory and anti-mutagenic activities of a prunus mahaleb L.anthocyanin-rich fruit extract[J].Journal of Functional Foods,2016: 537-548.DOI:10.1016/j.jff.2016.09.024.
[19] 李鑫.不同品种苹果多酚组分分析及其相关生物活性研究[D].杭州:浙江大学,2015.
[20] RAAFAT K,EL-D N,SALEH F A.Gastroprotective and anti-inflammatory effects of prunus cerasus phytochemicals and their possible mechanisms of action[J].Journal of Traditional and Complementary Medicine,2019.DOI: org/10.1016.
[21] 胡迎芬,孟洁,胡博路.紫叶李提取物的抗氧化活性及稳定性研究[J].食品科学,2002(08): 274-276.DOI: 10.3321/j.issn:1002-6630.2002.08.085.